Ufuk Şahin

مقالات Ufuk Şahin في مدونة RSS Kumru Automotive.

Drawing: an engine on the left and a plate-type oil cooler on the right; between them two blue hoses carrying coolant and two amber hoses carrying oil; oil drips from the crimp of the lower oil hose and has left a stain on the ground; the magnifier shows the inside of the cooler: oil passes into the coolant through a hole, marked in red, in the plate that separates the oil channel from the coolant channel

25 سبتمبر 2026الشاحنات

Oil cooler and transmission cooler line leaks: symptoms, oil in the coolant, and what happens if a line bursts

A leaking line puts oil on the outside; oil in the coolant points to a leak inside the cooler. Symptoms, what a burst does, and what to check.

Drawing: side view of a tractor unit with its cab tilted fully forward; behind it the cab’s drive position in dashed outline, above it the arc the cab travels, with top dead centre marked at the top of the arc; the tilt cylinder under the cab and the hand pump on the chassis; the magnifier shows the pump’s two-position selector valve set to tilt, with the pump lever fitted

22 سبتمبر 2026الشاحنات

How to tilt a truck cab: Mercedes-Benz, Volvo FH, DAF XG

How to tilt and lower a truck cab: preparation, selector valve, pumping and locking, with maker notes for Mercedes-Benz, Volvo FH and DAF XG.

Drawing: a hydraulic clutch circuit in side view: on the left the pedal resting on the floor (its normal position in dashed lines), the master cylinder and its reservoir; on the right the slave cylinder and the release fork on the transmission housing; the clutch hose joining the two has a red tear in the middle with drops of fluid below it; the magnifier shows the fluid running out through the tear in the hose

9 أغسطس 2026الشاحنات

What happens when a clutch hose bursts, and how to bleed a hydraulic clutch (trucks included)

A burst clutch hose drains the fluid: the pedal drops and the gears will not engage. Bleeding afterwards by pedal, by pressure bleeder and on a truck servo.

Drawing: a wheel and axle seen from behind; the chassis above, with a rigid brake pipe clipped beneath it; the flexible brake hose leaving the end of the pipe sags onto the axle and runs on to the brake caliper beside the wheel; the point of contact is marked in red; the magnifier shows the surface of the hose: on the left only cracks and chafe marks, on the right the outer cover worn through and the reinforcement (cords) showing beneath it

28 يوليو 2026الشاحنات

When does a brake hose need replacing? What counts as a defect at inspection

Inspection texts set no interval for a brake hose; they judge its condition. Exposed cords, bulging or a leak fail the test. Categories and a checking order.

Drawing: a hydraulic steering circuit; the steering gear, with its column and wheel on top, the pump and the fluid reservoir are joined by three lines: the supply line from reservoir to pump, the pressure line from pump to gear and the return line from the gear back to the reservoir; a bulge on the pressure line is marked in red, with fluid dripping from it; the magnifier shows the cracked, sweating surface of the hose

14 يوليو 2026الشاحنات

What happens when a truck power steering hose bursts? Replacement and bleeding

A burst hose drains the fluid and the assist goes; the truck still steers, heavily. Warning signs, what matters at replacement, and how to bleed.

Drawing: a discharge line falling without a dip from the compressor beside the engine to the air dryer on the chassis, with an air tank behind the dryer; the compressor is marked in red; the magnifier shows the line in cross-section: a thick layer of carbon coats the inner wall and only a narrow air passage is left in the middle

19 مايو 2026الشاحنات

Compressor discharge line: carbon, oil and slow air build-up

Carbon in the line between compressor and air dryer slows air build-up. Makers’ rules for length, bore and slope, when to replace it, what to check first.

Drawing: on a bench, the vehicle’s workshop manual and a cab tilt hand pump with its reservoir on top and the filler plug taken out; beside it two glass jars: clear oil in one, oil turned milky in the other, with water drops in it, marked in red; the magnifier looks into the reservoir through the filler opening: the oil covers the piston

5 مايو 2026الشاحنات

Cab tilt oil: which fluid goes in, and why it turns milky

Which oil goes in a cab tilt pump, is ATF allowed, and why does it turn milky? Fluids, level check and oil change from the makers’ own documents.

Drawing: a tractor unit with its cab lowered; on the chassis a hand pump with its lever moving, a full reservoir on top and two hoses running from the pump to the cylinder; the magnifier shows air bubbles in the oil inside the hose

9 فبراير 2026الشاحنات

How to bleed a cab tilt pump

A lever that moves while the cab stays put means air or low oil. The manufacturers’ bleed sequences, the reservoir rule and the safety points.

Drawing: a tractor unit with its cab tilted forward; the tilt cylinder under the cab, the hand pump on the chassis and the two hoses between them; the magnifier shows the push and pull hoses at the cylinder

23 سبتمبر 2025الشاحنات

Cab tilt hoses: choosing the right one, replacing it, and which end goes where

The two hoses do different jobs and cannot be swapped. Finding a hose by OE reference, a table of lengths and threads, replacement steps and the bleed sequence.

Drawing: a tractor unit with its cab stuck part-way; the places to check are marked in order: cab lock, selector valve, oil level and, last, the hand pump; the magnifier shows the tilt cylinder in section with oil leaking past the piston

19 يونيو 2025الشاحنات

Cab won’t tilt, won’t lower or creeps down: pump, cylinder or hose?

Which part is at fault when a cab will not tilt, lower or hold? A symptom table, the pump pressure test and the rule that spares the pump.

اطلب عرض أسعار لمشروعك.

يكفي إرسال الرسم الفني أو العيّنة أو رقم مرجع OEM. يُدرَس طلبك ونعود إليك بالسعر ومدة التوريد.

اطلب عرض أسعار بيانات الاتصال

06B145771P

كيف يسير طلب عرض الأسعار

ترسل رقم OEM أو الرسم الفني أو عيّنة.
نتحقق من التوافق.
نعود إليك بالسعر ومدة التوريد.