Süleyman Kumru

Beiträge von Süleyman Kumru im Blog von RSS Kumru Automotive.

Drawing: an old-type farm tractor from the side in pale outline; four lines leave the steering unit under the steering wheel: the T line returns to the oil tank at the front of the engine, the P line comes from the pump, and the L and R hoses go to the two ends of the steering cylinder at the front axle; the L and R hoses carry marking bands at their ends; the magnifier shows the four ports of the unit up close with the letters T, P, L and R

28. September 2026Traktoren

Fitting power steering to a tractor: hoses, pipes and which port goes where

Where the P, T, L and R ports of the steering unit go, which hose suits which line, what crossed lines do, and how to bleed on first start.

Drawing: the rear half of an old farm tractor from the side; the lift arms at the back are down; the levers beside the seat and the dipstick on the side of the housing are blue, they are checked first; inside the housing, oil and the pump at the bottom, the upright standpipe rising from the pump and the small cap in front of the seat; the magnifier shows the O-ring and the back-up washer on the end of the standpipe, with the cap taken off and the pipe pulled up

7. September 2026Traktoren

Massey Ferguson 135 / 240 hydraulic lift not working: standpipe, O-rings and the order of checks

Lift will not raise, raises slowly or will not hold a load: levers, oil and implement first, then the standpipe O-rings, the pump last.

Drawing: the fuel path of an old-type tractor engine from left to right: tank, glass-bowl pre-filter, lift pump with lever, filter, injection pump and the injector fed by a steel pipe; the filter screw, pump screw and injector union are marked first, then, last, with a single arrow above them running from the tank to the injectors; the magnifier shows fuel with bubbles coming out around a loosened screw

21. April 2026Traktoren

Bleeding a tractor fuel system: Massey Ferguson and Ford

Bleed from the tank towards the injectors. Bleed points and order for the Massey Ferguson 240 and Ford 2000–5000, from the makers’ books.

Drawing: three injectors side by side on top of a tractor engine with the thin leak-off line running across their tops; the two on the left are joined by a steel pipe with banjo bolts and washers, on the right short rubber hoses with clamps run between nipples, and the line goes back to the tank on the right; a crushed washer on the middle injector and a cracked hose end at the right-hand nipple are marked in red, with diesel dripping below them; the magnifier shows the cracked hose end with a new washer beside it

17. Dezember 2024Traktoren

Tractor injector leak-off line leaks: hose, washer or injector?

When a tractor’s leak-off line leaks, check the hose, the clamps and the banjo washers first. What the line does, where to look and how to refit it.

Drawing: three steps from left to right with two arrows between them: a riveted serial number plate, an open parts book in the middle and, on the right, a bent injector pipe with a nut at each end and a part number tag tied to it; one page of the book shows a plain diagram of four injector pipes, the other page holds lines of numbers; the magnifier shows two lines of the book: two separate numbers for the same cylinder, one used before and one after, with a small serial number plate on the dividing line between them; the numbers are shown as short dashes, not digits

22. Oktober 2024Traktoren

Finding the right pipe for a Massey Ferguson or Ford tractor by part number

Find the pipe by number, not model name: serial numbers, the parts book, what Massey Ferguson and Ford numbers look like, sets and single pipes.

Drawing: an old-type farm tractor from the side in pale outline (large rear wheel with its fender, small front wheel, long hood, upright exhaust, steering wheel, seat); two steel pipes run down from the steering pump and its oil reservoir at the front of the engine to the steering cylinder at the front axle, with a short flexible hose at each end; oil drips from a nut at the pump, and the place of the clamp that holds the two pipes together is empty and marked in red; the magnifier shows the nut slid back and oil seeping from a hairline crack in the pipe right where the nut sat

21. Mai 2024Traktoren

Tractor power steering line leaks: Ford 2000–5000 and Massey Ferguson 50 and 65

Check the connections, the steel pipe and the hose. Order of checks, clamps, topping up and bleeding, from Ford’s 2000–5000 service manual.

Angebot für Ihr Projekt

Es genügt, uns die technische Zeichnung, ein Muster oder die OEM-Referenznummer zu übermitteln. Ihre Anfrage wird geprüft; wir melden uns mit Angaben zu Preis und Liefertermin bei Ihnen.

Angebot anfordern Kontaktdaten

06B145771P

So läuft eine Anfrage ab

Sie senden die OEM-Nummer, eine technische Zeichnung oder ein Muster.
Wir prüfen die Passgenauigkeit.
Wir melden uns mit Preis und Lieferzeit.